Votes - 3, Average rating: 3.7
(
)
)
|
manual abstract
Smoke Evacuation Systems Operator’s Manual DELL PlumeSafe® Smoke Evacuation System Limited Warranty For a period of one (1) year following the date of delivery, BUFFALO FILTER warrants the Dell PlumeSafe® Evacuation System against any defects in material or workmanship. For a period of one (1) year following the date of delivery. BUFFALO FILTER will repair or replace (at BUFFALO FILTER’S option) the same without charge, provided that routine maintenance as specified in this manual has been performed using replacement parts approved by BUFFALO FILTER. This warranty is void if the product is used in a manner or for purposes other than intended. . 2004 BUFFALO FILTER® 595 Commerce Drive Buffalo, New York USA 14228 (716) 835-7000 Division of Medtek Devices, Inc. Customer Service: 800-343-2324 (U.S. Only) The revision level of this manual is specified by the highest revision letter found on either the inside front cover or enclosed errata pages (if any). Manual Number DPSEMAN Rev. A 4/2004 Unit Serial Number ______________________ Classified by Underwriters Laboratories, Inc.. with respect to electric shock, fire and mechanical hazards only in accordance with UL/IEC 60601 9D93 9D93 BUFFALO FILTER® Dell PlumeSafe® Smoke Evacuation System BUFFALO FILTER® Dell PlumeSafe® Smoke Evacuation System Section Title Page 1.0 SYSTEM DESCRIPTION 1.1 1.1 Introduction 1.1 1.2 Inspection 1.1 1.3 Operational Information 1.2 1.4 Cautions and Warnings 1.2 2.0 OPERATING INSTRUCTIONS 2.1 2.1 System Controls 2.1 2.2 ViroSafe. Filter Instructions 2.2 2.3 Set-up and Operation 2.3 2.4 Specifications 2.4 3.0 MAINTENANCE 3.1 3.1 General Maintenance Information 3.1 3.2 Cleaning 3.1 3.3 Periodic Inspection 3.1 3.4 Troubleshooting 3.1 4.0 CUSTOMER SERVICE 4.1 4.1 Equipment Return 4.1 4.2 Ordering Information 4.1 5.0 TERMS & WARRANTY 5.1 Table of Contents & List of Illustrations System Description Section 1.0 System Description Section 1.0 1.1 Introduction The Dell PlumeSafe® Smoke Evacuation Systems is designed to remove smoke and noxious odors produced by surgical ablation during laser procedures. The Dell PlumeSafe Smoke Evacuation Systems have been designed with a precision centrifugal action pump. The ultra-quiet motor is used to draw the surgical smoke from the surgical site through the vacuum tubing and into the ViroSafe. filter where the surgical smoke is processed by a series of three different filter stages. A single disposable filter is used to simplify the installation and removal during filter changes. The filter is completely enclosed to protect the healthcare personnel from potential contamination during filter changes. The first stage of filtration is a prefilter whose function is to trap and remove gross particulate and casual fluid. The second stage of filtration uses the highest grade virgin activated carbon, especially designed for Buffalo Filter for the removal and adsorption of odors and toxic gases produced by burning tissues. These harmful gases may constitute a health hazard to healthcare professionals who are subjected to prolonged exposure. The activated carbon used in the Dell PlumeSafe Smoke Evacuation Systems preferentially removes toxic organic gases rather than water vapor and provides optimal odor removal. The third stage of filtration is a ULPA (Ultra Low Penetration Air) filter whose high-tech patented design captures particulates and micro-organisms down to 0.12 .m at an efficiency of 99.99995%. Each. ULPA filter is certified before use. The electronic controls on the face panel of the Dell PlumeSafe smoke evacuation system is designed to be “user friendly” and facilitate easy unit set up and operation. Please refer to Section 2.0 for Operating Instructions. 1.2 Inspection The Dell PlumeSafe Smoke Evacuator has been thoroughly tested and inspected before shipment from the factory. Please check the unit before using it to insure that no damage has occurred in transit. If damage is evident, please contact BUFFALO FILTER Customer Service at 1-800-343-2324 (US Only) or (716) 8357000 (International). In addition, if you have ordered kit #DPSWKIT01, please compare the accessories you may have received with the standard accessories list below. If an item is missing, please notify BUFFALO FILTER Customer Service. Standard Accessories: • Operator’s Manual (1) • Power Cord (1) • ViroSafe Dell Filters (2) • Footswitch (1) • Asico Fixation Handpiece (2) • 3/8” x 10’ Tubing (2) Please contact BUFFALO FILTER Customer Service to purchase any additional accessories for your smoke evacuation system. BUFFALO FILTER® Dell PlumeSafe® Smoke Evacuation System BUFFALO FILTER® Dell PlumeSafe® Smoke Evacuation System 1.3 Operational Information The operational information contained in this section is intended for the customer review of regulatory issues. The information pertains to the use of the products both domestically and internationally: 1. The BUFFALO FILTER Dell PlumeSafe Smoke Evacuation System(s) complies with IEC601.1 el...