Votes - 4, Average rating: 4.5 ( )

Manafacture: Hobart File size: 1.44 mb File name: Language of manual:

Remove the rack (Fig. 8). Remove the grease filter (Fig. 8) at the rear of the oven chamber by lifting up and out. Remove the fan baffle (Fig. 9) by lifting up and out. Remove the rack retainer (Fig. 9) normally located under the grease filter and fan baffle. Wash the removed parts in a sink with warm soapy water, rinse with clear water, and dry with a clean dry cloth. Clean all areas of the oven and all parts. Reinstall the parts in their original positions. Rack Fan Baffle Grease Filter Rack Retainer PL-40542-1 PL-41364-1 Fig. 8 Fig. 9 If using the hose spray accessory to clean the oven interior, DISCONNECT ELECTRICAL POWER and avoid spraying near the controls. DO NOT use steel wool or abrasive scouring pads as they will scratch and ruin the oven surfaces. Sanitize the temperature probe. Return it to its home position in the bracket on the ceiling of the oven. – 27 – Complete Cleaning (continued) Complete Cleaning (continued) Wipe surfaces which touch the door gasket with a cloth or sponge and warm soapy water, rinse with warm clear water, and wipe with a dry cloth. CAUTION: Do not allow the door gasket to come in contact with food oils, petroleum solvents, lubricants, or caustic cleaners. For 6 and 10 level ovens, remove the condensate gutter (Fig. 10) by removing the two thumb screws that attach it to the bottom of the inside of the door frame. For 20 level ovens, the three segment condensate gutter may be removed for cleaning. Save the screws. Wash and rinse the condensate gutter in a sink with warm soapy water and a clear water rinse, and dry with a clean dry cloth. To reinstall condensate gutter: Reverse the removal procedure, align screw holes and tighten screws. Keep the cooking compartment drain (Fig. 10) working freely. After cooking grease producing foods, operate the oven with the compartment empty for 30 minutes at the end of the day, or slowly pour 1/2 gallon of warm soapy water down the drain, followed by 1/2 gallon of warm clear water. The drain grating may be removed for cleaning; replace it in its original position when done. Leave the door slightly open when the oven is not in use to allow the inside to dry out. PL-41379-1 Interior Glass Door Door Gasket Drain Grating Lower Snap Fastener Lower Hinge Upper Hinge Condensate Gutter (2 screws) Upper Snap Fastener Fig. 10 – 28 – MAINTENANCE WARNING: THE OVEN AND ITS PARTS ARE HOT. USE CARE WHEN OPERATING, CLEANING OR SERVICING THE OVEN. THE COOKING COMPARTMENT CONTAINS LIVE STEAM. STAY CLEAR WHEN OPENING DOOR. CLEAN CYCLE DELIMING PROCEDURE • With the Programmable Control, select the Clean Cycle [Program Number 00 and or Program Number 98 and . [ CC ] will display as the Program Number, [ dSCL ] will display in the Temperature Display. Push Start Stop. The indicator light in the Start Stop key will light. 1. The Steam Generator will drain, the oven will beep for 5 seconds, and [ 40 ] will display in the Time Display and the indicator light in the Start Stop key will turn off. • If the Kleensteam system is installed in the water line to the steam generator, remove the cartridge from the housing, install the dip tube and add the appropriate amount of ScaleKleen descaling chemicals for the Combi Model as specified in Column D or E of the following table. • If there is no Kleensteam system installed in the water line to the steam generator, add the amount of vinegar equal to the Tank Volume as specified in Column B or C of the following table. Add the vinegar to the steam generator tank through the opening in the oven cavity using the funnel and flexible tube provided with the oven. CLEAN CYCLE DELIMING — TANK VOLUME AND CHEMICAL REQUIREMENTS A. MODEL TANK VOLUME (U.S.GALLONS) C. TANK VOLUME (QUARTS) D. QUANTITY OF 7 oz. PACKETS OF SCALEKLEEN TO ACHIEVE 7 oz / gallon E. QUANTITY OF 2.2 lb. PACKETS OF SCALEKLEEN TO ACHIEVE 2.2 lb / five gallons HCE6H 0.8 gal. 3.2 qts. 0.8 packets or 5.6 oz. 0.16 packets or 5.6 oz. HCE10H 1.6 gal. 6.3 qts. 1.5 packets or 10.5 oz. 0.3 packets or 10.5 oz. HCE10F 1.6 gal. 6.3 qts. 1.5 packets or 10.5 oz. 0.3 packets or 10.5 oz. HCE20H 2.6 gal. 10.5 qts. 2.5 packets or 17.5 oz. 0.5 packets or 17.5 oz. HCE20F 3.4 gal. 13.7 qts. 3.4 packets or 24.0 oz. 0.7 packets or 24.0 oz. 2. Press the START button. The door closes and locks and the control cannot be interrupted until the Clean Cycle is finished. The oven cannot be turned off. If a power interruption occurs, the Clean Cycle will resume after power is restored. No other operations can be performed until the Clean Cycle is 'DONE'. • If the cavity temperature is above 212°F, automatic Cool Down will occur. During automatic Cool Down, the Time Display will show the rain symbol instead of time. The timer will start counting down. The steam generator will fill with water until the water level controls shut off the fill. The steam generator heater elements will produce steam for 30 minutes. After 30 minutes, the steam generator tank will drain. The Time Display will show 10 ...

Download now

Please, enter two numbers from picture: