Votes - 4, Average rating: 3.8
(
)
)
|
manual abstract
Keep it with your other important papers. ® INSTALLATION AND OPERATING INSTRUCTIONS 55505 Rev. B 07/99 PENINSULA MODEL VPN36 3-SIDED, WOODBURNING FIREBOX FOR YOUR SAFETY • Do not store or use gasoline or any other flammable vapors or liquids in the vicinity of this or any other appliance. • Due to high temperatures, the appliance should be located out of traffic and away from furniture and draperies. • Do not place clothing or other flammable materials on or near the appliance. • NEVER leave children unattended when a fire is burning in the firebox. WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE INJURY, PROPERTY DAMAGE, OR LOSS OF LIFE. REFER TO THIS MANUAL. FOR ASSISTANCE OR ADDITIONAL INFORMATION CONSULT A QUALIFIED INSTALLER OR LOCAL DISTRIBUTOR. WARNING: THIS FIREBOX IS INTENDED FOR USE WITH WOOD, OR IF A VENT-FREE OR DECORATIVE GAS APPLIANCE IS INSTALLED, BURN PROPANE/ LP OR NATURAL GAS ONLY. CHECK LOCAL CODES PRIOR TO INSTALLATION Model Serial No. Date Purchased DESA INTERNATIONAL, 2701 INDUSTRIAL DRIVE P.O. BOX 90004 BOWLING GREEN, KY 42102-9004 ® C O N T E N T S 1. INTRODUCTION......................................PG. 3 2. SELECTING LOCATION ......................... PG. 3 3. CLEARANCES ........................................ PG. 4 4. FRAMING ................................................PG. 4 5. HEARTH EXTENSIONS ..........................PG. 5 6. OUTSIDE AIR KIT INSTALLATION ........ PG. 6 7. GAS LINE INSTALLATION ..................... PG. 6 8. CHIMNEY PIPE INSTALLATION ............ PG .7 9. FINISHING YOUR CHIMNEY SYSTEM ..... PG. 9 10. TERMINATIONS.....................................PG. 11 11. FINISHING YOUR FIREBOX ................. PG. 12 12. OPERATING GUIDELINES AND MAINTENANCE INSTRUCTIONS ......... PG. 13 13. REPLACEMENT & ACCESSORY PARTS ... PG. 14 22 5/8 21 10 1/4 11 1/4 36 1/2 8 1/8 20 1/2 48 1/2 66 1/4 29 1/2 24 1/2 22 3/8 12HEARTH AREA DIMENSIONS 37 1/2 3/8 3/4 3/4 5/8 12 7 3 40 24 NAILING FLANGES OUTSIDE AIR HANDLE OTHER SIDE OUTSIDE AIR GAS LINE CONDUIT UL LABEL BEHIND DOOR ON SMOKE SHELF 19 12 O15 O.D. O10 I.D. NOTE: ALL DIMENSIONS IN THIS INSTALLATION MANUAL ARE IN INCHES UNLESS OTHERWISE SPECIFIED. 2 55505 INTRODUCTION Model VPN36 series is a woodburning firebox intended and approved for installation in either residential homes or buildings of standard construction. This wood burning fireplace complies with UL 127 as a FACTORY BUILT FIREPLACE and is listed and tested by Underwriters Laboratory Inc. This model is not for use in mobile homes. This firebox system requires the utilization of a Vanguard 10" double-wall, snap-lock flue pipe system. BRUSHED BRASS GLASS DOORS are standard with this firebox. Different style doors are offered as optional accessories (see last page). BE SURE TO CHECK WITH YOUR LOCAL BUILDING CODES FOR AREA REQUIREMENTS BEFORE INSTALLING THIS FIREBOX. The model's serial number and any other specific rating information may be found on the unit in the UL RATING PLATE located at the interior of the firebox's opening (see Figure 1, page 2). BEFORE YOU BEGIN Before beginning the installation of your firebox, read these instructions through completely. This firebox and its approved components are safe when installed and operated according to this installation and operation manual. Unless you use Vanguard approved components tested for this firebox, YOU MAY CAUSE A FIRE HAZARD! The DESA International warranty will be voided by, and DESA International disclaims any responsibility for the following actions: A) Modification of the firebox or any of the components manufactured by DESA INTERNATIONAL unless otherwise permitted by DESA INTERNATIONAL. B) The use of a firebox insert or any other component part not approved by DESA INTERNATIONAL in combination with a DESA INTERNATIONAL firebox. C) Installation and/or operation in a manner other than instructed in this manual. D) The burning of any other fuel not tested or approved by DESA INTERNATIONAL in this wood-burning firebox. PROPER INSTALLATION is the most important step in ensuring a safe and continuous operation of this firebox. Although grounding may not be required by code in your area, it must be electrically grounded in accordance with local codes or, in the absence of local codes, with the National Electrical Code, ANS/ NFPA 70-1987. This firebox is intended for installation in accordance with the National Fire Protection Association Standard for Chimneys, Fireplaces, Vents, and Solid-Fuel Burning Fireplaces, NFPA 211, and in accordance with codes such as the BOCA Basic/National Code, the Standard Mechanical Code, and the Uniform Building Code. NOTE: Installation and repair should be done by a qualified installer. The firebox and chimney system should be inspected and cleaned before use and periodically thereafter especially during heating season to ensure a safe operating system. This firebox is not intended to be used as a substitute for a furnace to heat an entire ...