Votes - 3, Average rating: 3.3
(
)
)
|
manual abstract
If sandblasting, it will cause the sand to cake and clog the gun, rendering it ineffective. A filter in the air line (MP3105), located as near to the gun as possible, will help eliminate this moisture. battery for 7 to 9 hours. If the unit is used too long after the yellow light comes on, recharging time could take up to 20 hours and the battery life may be shortened. 4. Do not operate the unit while recharging with the 120-volt AC adapter. Unit will not run while recharging. BATTERY INDICATOR LIGHTS Green, yellow and red lights show the battery condition. The green light indicates a charged battery. The yellow light indicates the battery is low and needs recharging. If the red light is on at any time, the unit will not operate. Do not leave the ! WARNING compressor unattended while the unit is running. Turn unit off to ! CAUTION allow compressor to cool for 20 minutes after 20 minutes of continuous operation. If not cooled properly, the compressor will overheat. After the battery is charged, the compressor is ready for use. If the battery has not been charged, see section on 120-VOLT AC CHARGING GREEN YELLOW RED BATTERY LIGHT LIGHT LIGHT INDICATION ON OFF OFF Full to Normal OFF ON OFF Weak-Needs Recharging OFF OFF ON Exhausted-Needs Recharging IMMEDIATELY Unit Will Not Operate OFF FLASHING FLASHING Unit Is On Charge and Will Not Operate before continuing. TIPS FOR LONGER BATTERY LIFE - Charge the battery for 14 hours before first using the compressor. Use the charging adapter provided. - Recharge within 48 hours of use. - Make sure battery is fully charged when storing. - Recharge every 3-5 months, even during periods of light or no use. - This product uses a sealed, rechargeable lead acid battery. The compressor has a small air reservoir and the pump is controlled by a pressure switch. When the internal pressure reaches approximately 100 psi, the pump will turn back on. 1. There is a 20 amp automotive type cartridge fuse inside the accessory storage cover. If the compressor fails to operate at all, check the fuse. 2. Internal safety valve will release if pressure exceeds 160 psi. This indicates a compressor problem. If this happens, do not operate compressor. Take it to an authorized Campbell Hausfeld Service Center. 3. There is a tank drain on the bottom of the compressor to remove moisture from the tank. Pressure should be be below 15 psi before opening drain valve. 4. Make sure that there are no leaks in the hose, attachments and fittings. If there are leaks, the pump will cycle as it replaces the lost air and will run the battery down. 3 Cordless Air Compressor Pre-Operation (Cont.) INDICATOR LIGHTS The indicator lights on the unit read as follows: Green. Fully charged and ready to run. Yellow. Partially discharged and operational. Red. Battery is low. Unit will not operate to protect battery. Yellow and Red Flashing. Unit is on charge and will not operate. Operation BREAK-IN PROCEDURE Do not attach air ! CAUTION chuck or other tool to open end of hose until start-up has been completed and unit checks OK. IMPORTANT: Do not operate compressor before reading instructions or damage may result. 1. Make sure fuse is installed. (See Pre-Operation section.) 2. Fully charge compressor until green light is on. 3. Turn switch to ON (I) position and run unit for 5 minutes to break in the pump parts. 4. Attach hose to compressor. 5. Attach chuck or other tool to open end of hose. The compressor is now ready to use. The switch should ! CAUTION be in the OFF (O) position when connecting or disconnecting the power cord from the adapter jack. Storage Store the compressor in a room with temperature between 65oF (18oC) and 75oF (24oC). Make sure the power switch is in the 'Off' position. Battery Disposal This product contains a rechargeable sealed lead-acid battery. The battery pack itself is recyclable. If a battery collection program does not exist in your area, call 1-800-543-6400 for battery disposal information. The environmental laws in some states require retailers to accept returns of rechargeable batteries for proper disposal. Check the state environmental laws before disposing of this product. Never throw the battery pack away in a standard receptacle or have it incinerated. Contact your local city officials for battery disposal information. Regulator 1. This regulator controls air pressure to the hose and attachment. 2. Turning knob clockwise increases air pressure at outlet. 3. Turning counterclockwise will lower air pressure at outlet. Wall Mounting This compressor is designed with an option to be hung on a wall for convenient storage. It can also be operated while in the hanging position if one of the following conditions is met: 1. If mounted on a wall, mounting hardware is secured into wood or masonry with suitable fasteners. 2. If mounted on drywall or gypsum board, toggle bolts or mounting anchors are strong enough and are properly secure to resist vibration from the compressor. On the...