Votes - 2, Average rating: 5 ( )

Manafacture: Brinkmann File size: 241.54 kb File name: Language of manual:

Propane gas is extremely flammable, follow these instructions: • Use only LP gas cylinders marked "Propane" which are U.S. Department of Transportation (DOT) certified. • Always use the gas pressure regulator supplied with this product which is regulated for an outlet pressure of 15 PSI; the use of other regulators or no regulator could result in dangerous gas leakage. • Check all gas connections by following directions in the "Gas Leak Testing" section of this manual. Never test for gas leaks with a lighted match or open flame. Do not operate this cooker with a gas leak. • Propane is heavier than air and can accumulate in low places. Keep propane tank, at all times, in a well ventilated area. If you smell gas – leave the area immediately and call for help. • Never use a hose that shows signs of cracking or damage. Replace hose every two years. • Do not use or store cooker near gasoline or other flammable liquids, gases or where flammable vapors may be present. • Never store propane tank in an enclosed area (house, garage, etc.). Store outdoors in a well ventilated, shaded area, away from any heat source or open flame and away from children’s reach. • Turn the cooker "OFF" with the propane tank valve; use the needle valves when lighting the burners and to adjust the flame. Read all warnings on or accompanying propane tank. • Disconnect the propane tank from the cooker when not in use. A safety plug should be placed in the propane tank valve. 7. Keep hands, face and hair away from burner. Use long matches or long-nosed lighter to light the burner. Do not wear loose clothing or allow long hair to hang freely while lighting or using cooker. 8. Only use flat bottom metal cookware and center evenly over burner. Never put an empty pan over an open flame; the bottom of the pan could melt. Do not use plastic, ceramic or glassware. Any pan larger than 14 1/2" may not sit properly on burner stand and could cause hot liquids to spill or overturn cooker. 9. Do not fill cookware beyond one-half full with liquid to allow room for the addition of food and to avoid boil-over of hot liquid. In some cases, depending on the weight or size of food, even less liquid will be required. If spill-over/boil-over occurs, check to make sure flame was not extinguished by liquid. Gas could accumulate causing a highly flammable, very dangerous situation. Allow gas to dissipate prior to relighting cooker. 10. In case of grease fire, do not use water to extinguish flame. Turn gas OFF at propane tank and use fire extinguisher approved for use with gas appliances or other appropriate means to extinguish flame. 11. Do not use this cooker on recreational vehicle or boat. 12. Do not use this cooker for other than its intended purpose. 13. Only use replacement/accessory parts manufactured by The Brinkmann Corporation. Repairs should be performed by The Brinkmann Corporation. 14. Properly dispose of all packaging materials. USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR COOKER. FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE. SAVE THIS MANUAL FOR FUTURE REFERENCE. WARNING 3 ASSEMBLY INSTRUCTIONS TOOLS REQUIRED TO ASSEMBLE YOUR COOKER: 2 Adjustable wrenches OR Adjustable wrench and the following wrenches: 3/8" Open end wrench 3/4" Open end wrench Step 1 Position the stand upside down as shown. Step 2 Attach wheels using the axle bolts and nuts. Tighten securely. Step 3 Set cooker with the burner assembly upright on a flat surface. Step 4 Using the 3/8" nuts and 3/8" x 1" bolts, attach the side tables. Tighten securely. Rotating Air Shutter Air Hole READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR COOKER. Inspect contents of the box to ensure all parts are included and undamaged. FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717. (Proof of purchase will be required.) PARTS LIST: 1 Cooker Stand 2 Wheels 2 Axle Bolts 2 Axle Nuts 2 Side Tables 4 3/8" x 1" Bolts 4 3/8" Nuts 3 2 4 5 6 7 1 3 2 4 5 6 7 1 NOTE: Make sure the male SAE fitting on the cooker is screwed into the air shutter and tightened securely. Do not over-tighten as the air shutter needs to move freely in order to adjust air intake. Check the attachment for proper connection every time propane tank is connected to cooker. INSTR-Outdoor Cooker.QXD 9/25/01 5:42 PM Page 4 INSTR-Outdoor Cooker.QXD 9/25/01 5:42 PM Page 5 GAS LEAK TESTING THE GAS LEAK TESTING PROCEDURE MUST BE PERFORMED EVERY TIME THE TANK IS CONNECTED TO COOKER. WARNING • • • • • Gas leak testing must be performed outdoors in a well ventilated area. During the gas leak testing procedure, always keep unit away from open flames, sparks or lit cigarettes. Never use a flame to check for gas leaks. Always use the propane tank valve to turn the unit OFF. The needle valves are used when lighting the burners and to adjust the flame. Never use a unit that has a gas leak. Contact The Brinkmann Corporatio...

Download now

Please, enter two numbers from picture: