Votes - 4, Average rating: 3.8
(
)
)
|
manual abstract
For that reason, a higher ratio of propane is desired in the gas mixture when temperatures drop below freezing. . 1.5.3 FUEL CONSUMPTION Model No Load 1/2 Load Full Load PRIMEPACT 50 (02010-2) 0.32 0.46 0.76 PRIMEPACT 50 LP (04164-2) 0.47/17.05 0.72/3.06 1.25/45.35 Gasoline is in gal/h. LP is in gal/h and cf/h. . 1.5.4 ENGINE OIL REQUIREMENTS Use only high quality detergent oil rated with American Petroleum Institute (API) Service Classification SF, SG or SH. The recommended oil weights include the following: • During summer months: SAE 30. An acceptable substitute is SAE 10W-30. • During winter months: SAE 5W-30. DO NOT USE SAE 10-W40. Crankcase and oil filter capacity is approximately 1,400 mL or 1.5 U.S. quarts. Do NOT use special additives. See Sections 3.1 and 3.2 (Page 12) for oil level check and fill procedures. 6 Generac® Power Systems, Inc. . 1.5.5 ENGINE Type of Engine ....................................GN-410, Single-cylinder Cooling Method..........................................................Air-cooled Rated Horsepower..........................................15 @ 4,200 rpm Displacement....................................................................407cc Cylinder Block ..........................Aluminum w/Cast Iron Sleeve Type of Governor ..............................Mechanical, Fixed Speed Air Cleaner..........................Paper Element w/Foam Precleaner Starter..........................................................12-volt DC Electric Ignition System........................Solid-state w/Flywheel Magneto Recommended Spark Plug Champion ..................................................................RC12YC AC....................................................................................R45S Fram Autolite ......................................................................65 Spark Plug Gap ........................................0.030 inch (76 mm) Recommended Minimum Battery ..............400 Cold-cranking Amperes . 1.5.6 GENERATOR Rated Maximum Continuous AC Output (Gasoline) ............................4,800 Watts (4.8 kW) AC Output (LP Fuel) ..............................4,500 Watts (4.5 kW) Rated Voltage ......................................................120 Volts AC* Rated Maximum Continuous AC Current (Gasoline) ......................................40 Amperes** AC Current (LP Fuel) ....................................37.5 Amperes** Phase ................................................................................Single Rotor RPM ........................................................................3,600 Number of Rotor Poles ............................................................2 Engine RPM ......................................................................2,571 Rated AC Frequency ........................................................60 Hz Battery Charge Voltage............................................14 Volts DC Battery Charge Current..................................2 Amperes (max) Weight Gasoline................................................................198 Pounds LP Fuel..................................................................200 Pounds Length ....................................................25.5 inches (648 mm) Width....................................................18.88 inches (479 mm) Height ..................................................16.75 inches (425 mm) *All units are reconnectable to 120- and/or 240-volt, dual voltage output. Units are no longer listed per RVIA/ANSI when reconnected for dual voltage output. **If reconnected for dual voltage, the ampere rating for 240 volts is 20 AC amperes for model PRIMEPACT 50 (02010-2), and 18.8 AC amperes for model PRIMEPACT 50 LP (04164-2). . 1.5.7 EMISSIONS COMPLIANCE PERIOD For non-handheld engines the Emissions Compliance Period referred to on the Emissions Compliance Label indicates the number of operating hours for which the engine has been shown to meet Federal emission requirements. • For engines less than 225 cc displacement, Category C=125 hours, B=250 hours, and A=500 hours. • For engines of 225 cc or more, Category C=250 hours, B=500 hours, and A=1000 hours. Generac® Power Systems, Inc. 7 Section 2 – Operation PRIMEPACT 50 Recreational Vehicle Generator 2.1 GENERATOR CONTROL PANEL The following features are mounted on the generator control panel (Figure 2.1): Figure 2.1 – Generator Control Panel 2.1.1 FUEL PRIMER Before starting a cold engine (if it has not been started in more than two weeks), you must press this switch for approximately 10 to 15 seconds to bring fuel from the tank to the carburetor. This rocker type switch springs back into its original position when you release it. It is not necessary to press the primer switch for LP units. 2.1.2 START/STOP SWITCH To crank and start the engine, hold this switch in the START position. Release the switch when the engine starts. To stop an operating engine, press and hold the switch in the STOP position unti...